For 1990-2009 cars only
HVAC
All Description and Operation
- Accumulator Description
- Air Conditioning (A/C) System Description
- Air Conditioning Evaporator Thermal Expansion Valve Description
- Air Distribution System Description
- Auxiliary Heater Circuit Description
- Auxiliary Heater Description
- Compressor Description
- Condenser Description
- Control Assembly Description
- Evaporator Description
- Expansion (Orifice) Tube Description
- Handling of Refrigerant Lines and Fittings
- Handling Refrigerant R-134a
- Heater Circuit Description
- Heater Core Description
- Heater System Description
- Maintaining Chemical Stability
- Modes Description
- O-Ring/Flat Washer Description
- Refrigerant R-134a
- Relays and Sensors Description
All Special Tools and Equipment
Diagnostic Procedures
- Air Delivery Improper
- Cold Drafts on Floor
- Defrosting Insufficient
- Heat Excessive
- Noise Diagnosis
- Vacuum System
General Diagnostic Information
- CCOT Air Conditioning (A/C) System Diagnosis
- Function Test
- Leak Testing
- Odor Diagnosis
- Refrigerant System Checks
- System Performance Test
Mechanical Specifications
- Compressor Specifications
- Fastener Tightening Specifications
- Fitting and Line Tightening Specifications
Other Specifications
Removal, Installation, and Replacement
- Accumulator Tube Replacement - Auxiliary Side
- Air Conditioning (A/C) High Pressure Cut-Out Switch Replacement
- Air Conditioning Accumulator Replacement
- Air Conditioning Clutch Coil Replacement
- Air Conditioning Compressor Shaft Seal Replacement
- Air Conditioning Condenser Replacement
- Air Conditioning Evaporator Core Replacement
- Air Distributor Duct Replacement
- Air Inlet Assembly Replacement
- Air Outlet Duct Replacement - Left Defogger
- Air Outlet Duct Replacement - Right Defogger
- Auxiliary Air Conditioning Compressor and Condenser Hose Replacement
- Auxiliary Air Conditioning Evaporator Front Tube Replacement
- Auxiliary Air Conditioning Evaporator Rear Tube Replacement
- Auxiliary Air Conditioning Evaporator Replacement
- Auxiliary Air Conditioning Evaporator Thermal Expansion Valve Replacement
- Auxiliary Air Outlet Duct Replacement
- Auxiliary Blower Motor and Fan Replacement
- Auxiliary Blower Motor Replacement
- Auxiliary Blower Motor Resistor Replacement
- Auxiliary Heater Core Replacement
- Auxiliary Heater Module Replacement
- Auxiliary Heater Pipe Replacement - Front
- Auxiliary Heater Pipe Replacement - Rear
- Blower Motor and Fan Replacement
- Blower Motor Relay Replacement
- Blower Motor Resistor Replacement
- Compressor Clutch Plate/Hub Assembly Replacement
- Compressor Pressure Relief Valve Replacement
- Compressor Sealing Washers Replacement
- Control Assembly Bulb Replacement
- Control Assembly Replacement
- Control Switch Replacement - Auxiliary
- Defroster Air Outlet Replacement
- Evaporator Tube Replacement
- Evaporator Tube Replacement - Auxiliary Side
- Expansion (Orifice) Tube Replacement
- Floor Air Outlet Duct Replacement - Left Side
- Floor Air Outlet Replacement - Center
- Floor Air Outlet Replacement - Right Side
- Heater Core Replacement
- Heater Hoses Replacement
- Heater Water Bypass Valve Replacement
- Lap Air Outlet Duct Replacement - Left Side
- Lap Air Outlet Duct Replacement - Right Side
- Mode Valve Actuator Replacement - Left Side
- Mode Valve Actuator Replacement - Right Side
- O-Ring Replacement
- Odor Correction
- Rear Floor Air Outlet Replacement
- Refrigerant Recovery and Recharging
- Sealing Washer Replacement
- Temperature Actuator Replacement
- Vacuum Hose Harness Replacement
- Vacuum Tank Replacement
