GM Service Manual Online
For 1990-2009 cars only
Makes 🢒 GMC_Truck 🢒 2001 🢒 Savana 🢒 General Information 🢒 Maintenance and Lubrication 🢒 Maintenance Schedule - Short Trip/City

Maintenance Schedule - Short Trip/City Gasoline

Important: Additional maintenance recommendations are in this subsection. Also refer to Owner Checks and Services , Periodic Maintenance Inspection .

The services shown in this schedule up to 166 000 km (100,000 mi) should be preformed after 166 000 km (100,000 mi) at the same intervals. The services shown at 240 000 km (150,000 mi) should be preformed at the same interval after 240 000 km (150,000 mi).

Footnotes

[Dagger] The U.S. Environmental Protection Agency or the California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle's useful life. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded.

# Lubricate the front suspension, kingpin bushings, steering linkage and rear driveline center splines.

+ A good time to check the brakes is during tire rotation. For brake system inspection, refer to Periodic Maintenance Inspection

** Drive axle service, for proper lubricant use refer to Fluid and Lubricant Recommendations

    • Check fluid level and add fluid as needed. If driving in dusty areas or when towing a trailer, drain fluid and refill every 25 000 km (150,000 miles)
    • If this vehicle has a locking differential, drain fluid and refill at first engine oil change.
    • More frequent lubrication may be required for heavy-duty use.

5 000 km (3,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

10 000 km (6,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +

15 000 km (9,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

20 000 km (12,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first).
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +

25 000 km (15,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the engine air cleaner filter if driving in dusty conditions. Replace filter if necessary.
        This is an Emission Control Service. [Dagger].
    • Inspect the axle fluid level. Add fluid as needed. **
    • Clean and repack the front wheel bearings (or each brake relining, whichever occurs first).
    •  Inspect the shields for damage or looseness (vehicles with GVWR above 10,000 lbs. or equipped with diesel engine only). Adjust or replace as required. Adjust or replace as required.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

30 000 km (18,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +

35 000 km (21,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

40 000 km (24,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +

45 000 km (27,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

50 000 km (30,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first).
    • Inspect the axle fluid level. Add fluid as needed. **
    • Clean and Repack the front wheel bearings (or each brake relining, whichever occurs first).
    • Replace the engine air cleaner filter.
        This is an Emission Control Service.
    • Replace the fuel filter.
        This is an Emission Control Service. [Dagger]
    • Inspect shields for damage or looseness. Adjust or replace as required. (Vehicles with GVWR above 10,000 lbs. or equipped with diesel engine only).
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.
    • Rotate the tires. +

55 000 km (33,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

60 000 km (36,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Rotate the tires. +
    • Inspect the axle fluid level. Add fluid as needed. **

65 000 km (39,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

70 000 km (42,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +

75 000 km (45,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **
    • Clean and repack the front wheel bearings (or each brake relining, whichever occurs first).
    • Inspect the engine air cleaner filter if driving in dusty conditions. Replace the filter if necessary.
        This is an Emission Control Service. [Dagger]
    •  Inspect the shields for damage or looseness. Adjust or replace as required (Vehicles with GVWR above 10,000 lbs. or equipped with diesel engine only).
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

80 000 km (48,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
         This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +

83 000 km (50,000 miles)

    • Change the automatic transmission fluid and the filter if the vehicle's GVWR exceeds 8600 lbs. or if the vehicle is mainly driven under one or more of the following conditions:
       - In heavy city traffic where the outside temperature regularly reaches 32° C (90° F) or higher.
       - In hilly or mountainous terrain.
       - When frequently towing a trailer.
       - Used as a taxi, police or delivery service vehicle.
    • If the vehicle is not used under any of these conditions, change the fluid and filter at 166,000 km (100,000 miles).

85 000 km (51,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first). This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

90 000 km (54,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first).
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +

95 000 km (57,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first). This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

100 000 km (60,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first).
    • Inspect the axle fluid level. Add fluid as needed. **
    • Clean and repack the front wheel bearings (or at each brake relining, whichever occurs first).
    • Inspect the shields for damage or looseness (Vehicles with GVWR above 10,000 lbs. or equipped with diesel engine only). Adjust or replace as required .
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.
    • Inspect engine accessory drive belt.
        This is an Emission Control Service.
    • Replace the fuel filter.
        This is an Emission Control Service.  [Dagger]
    • Conduct Exhaust Gas Recirculation (EGR) system inspection (if equipped).
        This is an Emission Control Service. [Dagger]
    • Conduct the evaporative control system inspection. Check all fuel and vapor lines and hoses for proper hook-up, routing and condition. Check that the purge valve works properly (if equipped). Replace as needed.
        This is an Emission Control Service. [Dagger]
    • Replace the engine air cleaner filter.
        This is an Emission Control Service.
    • Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed.
        This is an Emission Control Service. [Dagger]
    • Rotate the tires. +

105 000 km (63,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

110 000 km (66,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
         This an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first).
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +

115 000 km (69,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first).
    • Inspect the axle fluid level. Add fluid as needed. **

120 000 km (72,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +

125 000 km (75,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Clean and repack the front wheel bearings (or each brake relining, whichever occurs first).
    • Inspect the engine air cleaner filter if driving in dusty conditions. Replace the filter if necessary.
        This is an Emission Control Service. [Dagger]
    • Inspect the axle fluid level. Add fluid as needed. **
    • Inspect the shields for damage or looseness (Vehicles with GVWR above 10,000 lbs. or equipped with diesel engine only). Adjust or replace as required.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States .

130 000 km (78,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first).
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +

135 000 km (81,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

140 000 km (84,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first).
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +

145 000 km (87,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

150 000 km (90,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **
    • Clean and repack the front wheel bearings (or each brake relining, whichever occurs first).
    • Replace the fuel filter.
        This is an Emission Control Service. [Dagger]
    • Replace the engine air cleaner filter.
        This is an Emission Control Service.
    • Rotate the tires. +
    •  Inspect the shields for damage or looseness (Vehicles with GVWR above 10,000 lbs. or equipped with diesel engine only). Adjust or replace as required.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States .

155 000 km (93,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

160 000 km (96,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed.
    • Rotate the tires. +

165 000 km (99,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #.
    • Inspect the axle fluid level. Add fluid as needed. **

166 000 km (100,000 miles)

    • Inspect the spark plug wires.
        This is an Emission Control Service.
    • Replace the spark plugs.
        This is an Emission Control Service *
    • Change the automatic transmission fluid and the filter if the vehicle has a diesel engine, if the vehicles GVWR exceeds 8600 lbs. or if the vehicle is mainly driven under one or more of these conditions:
       - In heavy city traffic where the outside temperature regularly reaches 32°C (90°F) or higher
       - In hilly or mountainous terrain.
       - When doing frequent trailer towing.
       - Uses such a found in taxi, police or delivery service.
    • If this vehicle has not been used under the severe service conditions listed previously and therefore, the automatic transmission fluid has not been changed, change both the fluids and the filter.
    • Inspect the Positive Crankcase Ventilation (PCV) Valve.
        This is an Emission Control Service.

240 000 km (150,000 Miles)

    • Drain, flush and refill cooling system (or every 60 months since last service, whichever occurs first).
    • Inspect the radiator and heater hoses.
    • Clean the radiator, condenser, pressure cap and neck. Pressure test the cooling system and pressure cap.
        This is an emission control service.

Maintenance Schedule - Short Trip/City Diesel

Important: Additional maintenance recommendations are in this subsection. Also refer to Owner Checks and Services , Periodic Maintenance Inspection .

The services shown in this schedule up to 166 000 km (100,000 mi) should be preformed after 166 000 km (100,000 mi) at the same intervals. The services shown at 240 000 km (150,000 mi) should be preformed at the same interval after 240 000 km (150,000 mi).

Footnotes

[Dagger] The U.S. Environmental Protection Agency or the California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle's useful life. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded.

# Lubricate the front suspension, kingpin bushings, steering linkage and rear driveline center splines.

+ A good time to check the brakes is during tire rotation. For brake system inspection, refer to Periodic Maintenance Inspection

** Drive axle service, for proper lubricant use refer to Fluid and Lubricant Recommendations .

    • Check fluid level and add fluid as needed. If driving in dusty areas or when towing a trailer, drain fluid and refill every 25 000 km (150,000 miles).
    • If this vehicle has a locking differential, drain fluid and refill at first engine oil change.
    • More frequent lubrication may be required for heavy-duty use.

5 000 km (3,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

10 000 km (6,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +

15 000 km (9,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

20 000 km (12,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first).
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +

25 000 km (15,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the engine air cleaner filter if driving in dusty conditions. Replace filter if necessary.
        This is an Emission Control Service. [Dagger].
    • Inspect the axle fluid level. Add fluid as needed. **
    • Clean and repack the front wheel bearings (or each brake relining, whichever occurs first).
    •  Inspect the shields for damage or looseness (vehicles with GVWR above 10,000 lbs. or equipped with diesel engine only). Adjust or replace as required. Adjust or replace as required.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.
    • Check the air intake system installation to assure that gaskets are properly sealed and that all hose connections, fasteners and other components are tight. Also check to be sure that the air cleaner housing is properly seated and the cover fits tightly. Tighten connections and fasteners or replace damaged parts as necessary.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.
    • If this engine has a thermostatically controlled cooling fan, inspect all hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be sure the valve works properly.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States,

30 000 km (18,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +

35 000 km (21,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

40 000 km (24,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +
    • Replace the filler cap if driving in dusty conditions.
        This is an Emission Control Service.

45 000 km (27,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

50 000 km (30,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first).
    • Inspect the axle fluid level. Add fluid as needed. **
    • Clean and Repack the front wheel bearings (or each brake relining, whichever occurs first).
    • Replace the engine air cleaner filter.
        This is an Emission Control Service.
    • Replace the fuel filter.
        This is an Emission Control Service. [Dagger]
    • Inspect shields for damage or looseness. Adjust or replace as required. (Vehicles with GVWR above 10,000 lbs. or equipped with diesel engine only).
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.
    • Rotate the tires. +
    • Check the air intake system installation to assure that gaskets are properly sealed and that all hose connections, fasteners and other components are tight. Also check to be sure that the air cleaner housing is properly seated and the cover fits tightly. Tighten connections and fasteners or replace damaged parts as necessary.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.
    • If you engine has a thermostatically controlled cooling fan, inspect all hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be sure the valve works properly.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

55 000 km (33,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

60 000 km (36,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Rotate the tires. +
    • Inspect the axle fluid level. Add fluid as needed. **

65 000 km (39,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

70 000 km (42,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +

75 000 km (45,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **
    • Clean and repack the front wheel bearings (or each brake relining, whichever occurs first).
    • Inspect the engine air cleaner filter if driving in dusty conditions. Replace the filter if necessary.
        This is an Emission Control Service. [Dagger]
    •  Inspect the shields for damage or looseness. Adjust or replace as required (Vehicles with GVWR above 10,000 lbs. or equipped with diesel engine only).
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.
    • Check the air intake system installation to assure that gaskets are properly sealed and that all hose connections, fasteners and other components are tight. Also check to be sure that the air cleaner housing is properly seated and the cover fits tightly. Tighten connections and fasteners or replace damaged parts as necessary.
        This is a Noise Emission Control Service. Applicable only to vehicles sod in the United States.
    • If your engine has a thermostatically controlled cooling fan, inspect all hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be sure the valve works properly.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

80 000 km (48,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
         This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +
    • Replace the fuel filler cap if vehicle is driven in dusty conditions.
        This is an Emission Control Service.

83 000 km (50,000 miles)

    • Change the automatic transmission fluid and the filter if the vehicle's GVWR exceeds 8600 lbs. or if the vehicle is mainly driven under one or more of the following conditions:
       - In heavy city traffic where the outside temperature regularly reaches 32° C (90° F) or higher.
       - In hilly or mountainous terrain.
       - When frequently towing a trailer.
       - Used as a taxi, police or delivery service vehicle.
    • If the vehicle is not used under any of these conditions, change the fluid and filter at 166,000 km (100,000 miles).

85 000 km (51,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first). This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

90 000 km (54,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first).
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +

95 000 km (57,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first). This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

100 000 km (60,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first).
    • Inspect the axle fluid level. Add fluid as needed. **
    • Clean and repack the front wheel bearings (or at each brake relining, whichever occurs first).
    • Inspect the shields for damage or looseness (Vehicles with GVWR above 10,000 lbs. or equipped with diesel engine only). Adjust or replace as required .
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.
    • Inspect engine accessory drive belt.
        This is an Emission Control Service.
    • Replace the fuel filter.
        This is an Emission Control Service.  [Dagger]
    • Conduct Exhaust Gas Recirculation (EGR) system inspection (if equipped).
        This is an Emission Control Service. [Dagger]
    • Conduct the evaporative control system inspection. Check all fuel and vapor lines and hoses for proper hook-up, routing and condition. Check that the purge valve works properly (if equipped). Replace as needed.
        This is an Emission Control Service. [Dagger]
    • Replace the engine air cleaner filter.
        This is an Emission Control Service.
    • Rotate the tires. +
    • Check the air intake system installation to assure that gaskets are properly sealed and that all hose connections, fasteners and other components are tight. Also check to be sure that the air cleaner housing is properly seated and the cover fits tightly. Tighten the connections and fasteners or replace damaged parts as necessary.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.
    • If this engine has a thermostatically controlled cooling fan, inspect all hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be sure that the valve works properly.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.
    • Check the crankcase depression regulator valve system for any worn, plugged or collapsed hoses.
        This is an Emission Control Service.

105 000 km (63,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

110 000 km (66,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
         This an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first).
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +

115 000 km (69,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first).
    • Inspect the axle fluid level. Add fluid as needed. **

120 000 km (72,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +
    • Replace the fuel fill cap if driving in dusty conditions.
        This is an Emission Control Service.

125 000 km (75,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Clean and repack the front wheel bearings (or each brake relining, whichever occurs first).
    • Inspect the engine air cleaner filter if driving in dusty conditions. Replace the filter if necessary.
        This is an Emission Control Service. [Dagger]
    • Inspect the axle fluid level. Add fluid as needed. **
    • Inspect the shields for damage or looseness (Vehicles with GVWR above 10,000 lbs. or equipped with diesel engine only). Adjust or replace as required.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States .
    • Check the air intake system installation to assure that gaskets are properly sealed and that all hose connections, fasteners and other components are tight. Also check to be sure that the air cleaner housing is properly seated and the cover fits tightly. Tighten the connections and fasteners or replace damaged parts as necessary.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

130 000 km (78,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first).
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +

135 000 km (81,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

140 000 km (84,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first).
    • Inspect the axle fluid level. Add fluid as needed. **
    • Rotate the tires. +

145 000 km (87,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

150 000 km (90,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **
    • Clean and repack the front wheel bearings (or each brake relining, whichever occurs first).
    • Replace the fuel filter.
        This is an Emission Control Service. [Dagger]
    • Replace the engine air cleaner filter.
        This is an Emission Control Service.
    • Rotate the tires. +
    •  Inspect the shields for damage or looseness (Vehicles with GVWR above 10,000 lbs. or equipped with diesel engine only). Adjust or replace as required.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States .
    • Check the air intake system installation to assure that gaskets are properly sealed and that all hose connections, fasteners and other components are tight. Also check to be sure that the air cleaner housing is properly seated and the cover fits tightly. Tighten the connections and fasteners or replace damaged parts as necessary.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.
    • If this engine has a thermostatically controlled cooling fan, inspect all hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be sure the valve works properly.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

155 000 km (93,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed. **

160 000 km (96,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #
    • Inspect the axle fluid level. Add fluid as needed.
    • Rotate the tires. +
    • Replace the fuel fill cap if driving in dusty conditions.
        This is an Emission Control Service.

165 000 km (99,000 miles)

    • Change the engine oil and the filter (or every 3 months, whichever occurs first).
        This is an Emission Control Service.
    • Lubricate the chassis components (or every 3 months, whichever occurs first). #.
    • Inspect the axle fluid level. Add fluid as needed. **

166 000 km (100,000 miles)

    • Change the automatic transmission fluid and the filter if the vehicle has a diesel engine, if the vehicles GVWR exceeds 8600 lbs. or if the vehicle is mainly driven under one or more of these conditions:
       - In heavy city traffic where the outside temperature regularly reaches 32°C (90°F) or higher
       - In hilly or mountainous terrain.
       - When doing frequent trailer towing.
       - Uses such a found in taxi, police or delivery service.
    • If this vehicle has not been used under the severe service conditions listed previously and therefore, the automatic transmission fluid has not been changed, change both the fluids and the filter.

240 000 km (150,000 Miles)

  1. Drain, flush and refill cooling system (or every 60 months since last service, whichever occurs first).
  2. Inspect the radiator and heater hoses.
  3. Clean the radiator, condenser, pressure cap and neck. Pressure test the cooling system and pressure cap.

    4. This is an emission control service.