GM Service Manual Online
For 1990-2009 cars only
Makes 🢒 GMC_Truck 🢒 2002 🢒 GMC K Sierra - 4WD 🢒 Bulletins 🢒 Noise from Steering at Low Speeds - keywords assist bearing bump chatter clunk column EVO gear linkage moan shaft turn vibration

Noise from Steering at Low Speeds - keywords assist bearing bump chatter clunk column EVO gear linkage moan shaft turn vibration

Subject:Noise From Steering at Low Speeds

Models:2001-2002 Chevrolet Silverado
2001-2002 GMC Sierra
with GVWR above 8600


The following diagnosis might be helpful if the vehicle exhibits the symptom(s) described in this PI.

Condition/Concern:

Note: This does not apply to Light Duty Trucks under 8600 GVWR.

Rattle, noise emanating from the steering column, particularly during low speed parking lot maneuvers.

Recommendation/Instructions:
  1. Verify noise is from stub shaft bearing area.
  2. Replace stub shaft bearing with kit part number 26099860.

Also, a special tool is required to complete the repair. You must use Essential Tool J-45798 to avoid damage to the bearing seal. The repair procedures are available in SI to install the new bearing.

Please follow this diagnostic or repair process thoroughly and complete each step. If the condition exhibited is resolved without completing every step, the remaining steps do not need to be performed.