| Table 1: | No Crank |
| Table 2: | Crank OK, But Too Slow |
| Table 3: | Starter Motor Does Not Stop |
| Table 4: | Starter Motor Running, But Not Cranking |
| Table 5: | Overcharging Battery |
| Table 6: | Battery Discharge |
| Table 7: | Charging Indicator Lamp Does Not Work When the Ignition Switch is ON - Engine Does Not Work |
| Table 8: | Charging Indicator Lamp Does Not Put Out Lights After Starting the Engine |
| Table 9: | Hard to Start the Engine |
| Table 10: | Engine Idling State is Unstable |
| Table 11: | Poor Engine Accelerating |
Checks | Actions |
|---|---|
Low battery voltage | Charging the battery or replace the battery. |
Battery cable is loose, corroded, or damaged. | Repair or replace the battery cable. |
Faulty starter motor or starter motor circuit is open. | Repair or replace the starter motor/starter motor circuit. |
Faulty ignition switch or fuse Ef2 is blown. | Replace the ignition switch or fuse Ef2. |
Ground short | Repair the ground short. |
Checks | Actions | ||||
|---|---|---|---|---|---|
Low battery voltage | Charging the battery or replace the battery. | ||||
| Repair or replace the battery cable. | ||||
Faulty starter motor | Repair or replace the starter motor. |
Checks | Actions |
|---|---|
Faulty starter motor | Repair or replace the starter motor. |
Faulty ignition switch | Replace the ignition switch. |
Checks | Actions |
|---|---|
Broken clutch pinion gear or faulty starter motor | Replace the starter motor. |
Broken flywheel ring gear | Replace the flywheel. |
Connected circuit is open. | Repair the open circuit. |
Checks | Actions |
|---|---|
Faulty IC regulator | Replace the IC regulator. |
Checks | Actions |
|---|---|
Loosen the generator drive belt. | Adjust the belt tension or replace the belt. |
The circuit is open or shorted. | Repair the open or shorted circuit. |
Faulty IC regulator | Replace the IC regulator. |
Battery run down | Replace the battery. |
Open ground circuit | Repair the open ground circuit. |
Checks | Actions |
|---|---|
Fault IC regulator | Replace the IC regulator. |
Charging indicator lamp is blown or fuse F8 is blown. | Repair or replace the charging indicator lamp/fuse F8. |
Faulty ignition switch | Replace the ignition switch. |
Generator ground circuit is open or shorted. | Repair the circuit. |
Checks | Actions |
|---|---|
Faulty IC regulator | Replace the IC regulator. |
Battery cable is corroded or damaged. | Repair or replace the battery cable. |
Loosen the generator drive belt. | Adjust the belt tension or replace the belt. |
Faulty wiring harness | Repair the wiring harness. |
Checks | Actions |
|---|---|
Faulty ignition coil | Replace the ignition coil. |
Faulty distributor,include the optical sensor | Replace the distributor or the optical sensor. |
Faulty spark plug | Replace the spark plug or adjust the gap. |
Poor ignition timing | Reset the valve timing. |
Checks | Actions |
|---|---|
Faulty spark plug | Replace the spark plug or adjust the gap. |
Faulty ignition coil | Replace the ignition coil. |
Poor ignition timing | Reset the valve timing. |
Checks | Actions |
|---|---|
Poor ignition timing | Reset the valve timing. |
