Caution: Be very careful when handling the sensors during service procedures. Never strike the sensors. Never jar the sensors. These actions could result in personal injury, or improper operation of the Supplemental Inflatable Restraint (SIR) system. Carefully tighten all of the sensors, and all of the mounting bracket bolts to ensure proper operation. Never power up the SIR system when any one of the sensors is not rigidly attached to the vehicle. An unattached sensor could be easily activated causing the deployment of the air bag.

Use caution to ensure proper location of sensor on the mounting brackets. Do not for any reason modify the keying of the sensors through the wiring harness connectors.

1. Disable the SIR system. Refer to Disabling the SIR System .



2. Disconnect the Connector Position Assurance (CPA) lock from the connector.



3. Disconnect the connector.



4. Drill out the mounting rivets.



5. Remove the sensor from the vehicle.

Important: If the sensor mounting holes or fasteners are damaged to the extent the sensor can no longer be properly mounted, use the following repairs.

First Repair

1. Remove the improperly installed rivet.
2. Reattach sensor with new rivet P/N 15955523.

Second Repair

1. Remove the improperly installed rivet.
2. Enlarge the mounting holes in the lower radiator support to 9.0 mm (0.35 in).



3. Insert and properly seat rivnut P/N 15699834

Install sensor with screw P/N 11515664.

Tighten
Tighten the sensor screws to 8.0 N·m (71 lb in).

Refer to Fastener Notice in General Information.

Caution: Attach the forward discriminating sensor rigidly to the vehicle structure, in order to ensure that the sensor operates properly. Make sure the arrow on the sensor points toward the front of the vehicle.

1. Install sensor to vehicle. Arrow must point toward the front of the vehicle.



2. Install rivets P/N 15955523.



3. Connect the sensor electrical connector.



4. Connect the Connector Position Assurance (CPA) lock.
5. Enable the SIR System. Refer to Enabling the SIR System .