GM Service Manual Online
For 1990-2009 cars only

Engine is Hard to Start After Filling the Fuel Tank - keywords controls crank EVAP extended gas long no P0440 P0442 P0446 P0455 purge valve vapor

Subject:Engine is Hard to Start After Filling the Fuel Tank

Models:2004-2005 Buick Rainier
2002-2005 Chevrolet TrailBlazer
2002-2005 GMC Envoy
2002-2004 Oldsmobile Bravada
with 4.2L Engine (VIN S - RPO LL8)



The following diagnosis might be helpful if the vehicle exhibits the symptom(s) described in the PI.

Condition/Concern:

On rare occasions, an extended crank or hard to start condition may be experienced after filling the fuel tank. A SES light with EVAP DTCs may or may not be experienced with this condition. This may be the result of an EVAP purge valve that is not fully seated in the closed position with the engine off.

Recommendation/Instructions:

If the SI diagnostics do not isolate the cause of this concern, apply vacuum to either side of the EVAP purge valve using a handheld vacuum pump while the engine is off to determine if it holds vacuum. If the EVAP purge valve does not hold vacuum, replace the EVAP purge valve, which is on the left side of the engine.

Please follow this diagnosis process thoroughly and complete each step. If the condition exhibited is resolved without completing every step, the remaining steps do not need to be performed.