GM Service Manual Online
For 1990-2009 cars only

Diagnostic Instructions

    • Perform the Diagnostic System Check - Vehicle prior to using this diagnostic procedure.
    • Review Strategy Based Diagnosis for an overview of the diagnostic approach.
    •  Diagnostic Procedure Instructions provides an overview of each diagnostic category.

DTC Descriptors

DTC B0228 02 : Recirculate Position Feedback Circuit Short to Ground

DTC B0228 05 : Recirculate Position Feedback Circuit Short to Battery or Open

DTC B0228 61 : Recirculate Position Circuit Actuator Stuck

DTC B0413 02 : Temperature Control 1 Feedback Circuit Short to Ground

DTC B0413 05 : Temperature Control 1 Feedback Circuit Short to Battery or Open

DTC B0413 61 : Temperature Control 1 Feedback Circuit Actuator Stuck Open

DTC B0423 02 : Temperature Control 2 Feedback Circuit Short to Ground

DTC B0423 05 : Temperature Control 2 Feedback Circuit Short to Battery or Open

DTC B0423 61 : Temperature Control 2 Circuit Actuator Stuck

DTC B0433 02 : Temperature Control 3 Feedback Circuit Short to Ground

DTC B0433 05 : Temperature Control 3 Feedback Circuit Short to Battery or Open

DTC B0433 61 : Temperature Control 3 Circuit Actuator Stuck

DTC B3779 02 : Air Flow Control 9 Feedback Circuit Short to Ground

DTC B3779 05 : Air Flow Control 9 Feedback Circuit Short to Battery or Open

DTC B3779 61 : Air Flow Control 9 Circuit Actuator Stuck

DTC B3782 02 : Air Flow Control 10 Feedback Circuit Short to Ground

DTC B3782 05 : Air Flow Control 10 Feedback Circuit Short to Battery or Open

DTC B3782 61 : Air Flow Control 10 Circuit Actuator Stuck

Diagnostic Fault Information

Circuit

Short to Ground

Open/High Resistance

Short to Voltage

Signal Performance

Recirculation 5-Volt Reference

B0228 02 , B0413 02 , B0423 02, B0433 02, B0228 02, B3782 02 or B3779 02

B0228 05

B0228 02, B0413 02, B0423 02, B0433 02, B0228 02, B3782 02 or B3779 02

B0228 61

Recirculation Door Position Signal

B0228 02

B0228 05

B0228 05

B0228 61

Recirculation Door Control A

B0228 02

B0228 05

B0228 05

B0228 61

Recirculation Door Control B

B0228 02

B0228 05

B0228 05

B0228 61

Recirculation Low Reference

B0228 02

B0228 05

B0228 05

B0228 61

Driver Air Temperature 5-Volt Reference

B0228 02, B0413 02, B0423 02, B0433 02, B0228 02, B3782 02 or B3779 02

B0413 05

B0228 2, B0413 02, B0423 02, B0433 02, B0228 02, B3782 02 or B3779 02

B0413 61

Driver Air Temperature Door Position Signal

B0413 02

B0413 05

B0413 05

B0413 61

Driver Air Temperature Door Control A

B0413 02

B0413 05

B0413 05

B0413 61

Driver Air Temperature Door Control B

B0413 02

B0413 05

B0413 05

B0413 61

Driver Air Temperature Low Reference

B0413 02

B0413 05

B0413 05

B0413 61

Passenger Air Temperature 5-Volt Reference

B0228 02, B0413 02, B0423 02, B0433 02, B0228 02, B3782 02 or B3779 02

B0423 05

B0228 02, B0413 02, B0423 02, B0433 02, B0228 02, B3782 02 or B3779 02

B0423 61

Passenger Air Temperature Door Position Signal

B0423 02

B0423 05

B0423 05

B0423 61

Passenger Air Temperature Door Control A

B0423 02

B0423 05

B0423 05

B0423 61

Passenger Air Temperature Door Control B

B0423 02

B0423 05

B0423 05

B0423 61

Passenger Air Temperature Low Reference

B0423 02

B0423 05

B0423 05

B0423 61

Mode 5-Volt Reference

B0228 02, B0413 02, B0423 02, B0433 02, B0228 02, B3782 02 or B3779 02

B3779 05

B0228 02, B0413 02, B0423 02, B0433 02, B0228 02, B3782 02 or B3779 02

B3779 61

Mode Door Position Signal

B3779 02

B3779 05

B3779 05

B3779 61

Mode Door Control A

B3779 02

B3779 05

B3779 05

B3779 61

Mode Door Control B

B3779 02

B3779 05

B3779 05

B3779 61

Mode Low Reference

B3779 02

B3779 05

B3779 05

B3779 61

Auxiliary Air Temperature 5-Volt Reference

B0228 02, B0413 02, B0423 02, B0433 02, B0228 02, B3782 02 or B3779 02

B0433 05

B0228 02, B0413 02, B0423 02, B0433 02, B0228 02, B3782 02 or B3779 02

B0433 61

Auxiliary Air Temperature Door Position Signal

B0433 02

B0433 05

B0433 05

B0433 61

Auxiliary Air Temperature Door Control A

B0433 02

B0433 05

B0433 05

B0433 61

Auxiliary Air Temperature Door Control B

B0433 02

B0433 05

B0433 05

B0433 61

Auxiliary Air Temperature Low Reference

B0433 02

B0433 05

B0433 05

B0433 61

Auxiliary Mode 5-Volt Reference

B0228 02, B0413 02, B0423 02, B0433 02, B0228 02, B3782 02 or B3779 02

B3782 05

B0228 2, B0413 02, B0423 02, B0433 02, B0228 02, B3782 02 or B3779 02

B3782 61

Auxiliary Mode Door Position Signal

B3782 02

B3782 05

B3782 05

B3782 61

Auxiliary Mode Door Control A

B3782 02

B3782 05

B3782 05

B3782 61

Auxiliary Mode Door Control B

B3782 02

B3782 05

B3782 05

B3782 61

Auxiliary Mode Low Reference

B3782 02

B3782 05

B3782 05

B3782 61

Circuit/System Description

The actuators operate using 5 circuits. A 5-volt reference, low reference, signal circuit and two bi-directional 0 or 12 volt control circuits. The HVAC control module supplies a low reference and 5-volt reference to the potentiometer. The HVAC control module monitors the voltage drop across the potentiometer on the door position signal circuit. As the actuator door changes position the door position signal circuit voltage also changes. The two bi-directional control circuits enable the actuator to operate. Both circuits are set to 0 volts when the HVAC control module detects, from the feedback potentiometer, that the actuator is in the desired position. In order to move the actuator, the HVAC control module switches the appropriate control circuit to 12 volts.

    • DTC B0228 is for the recirculate actuator
    • DTC B0413 is for the left air temperature actuator
    • DTC B0423 is for the right air temperature actuator
    • DTC B0433 is for the auxiliary air temperature actuator
    • DTC B3782 is for the auxiliary mode actuator
    • DTC B3779 is for the mode actuator

Conditions for Running the DTC

    • The ignition is ON.
    • The HVAC module is ON.

Conditions for Setting the DTC

The actual door position differs from the commanded door position by more than 4 counts or the HVAC control module detects the door position signal circuit is less than 3 counts or greater than 253 counts.

Action Taken When the DTC Sets

The control circuit is deactivated for the appropriate actuator.

Conditions for Clearing the DTC

    • The DTC becomes history when the HVAC control module no longer detects the condition that set the DTC.
    • The history DTC will clear after 100 fault-free ignition cycles.

Reference Information

Schematic Reference

HVAC Schematics

Connector End View Reference

Component Connector End Views

Description and Operation

    •  Air Delivery Description and Operation
    •  Air Temperature Description and Operation

Electrical Information Reference

    •  Circuit Testing
    •  Connector Repairs
    •  Testing for Intermittent Conditions and Poor Connections
    •  Wiring Repairs

Scan Tool Reference

Control Module References for scan tool information

Circuit/System Verification

Ignition ON, command the appropriate actuator in both directions with a scan tool. The scan tool door position parameter reading should be between 3 and 253 counts.

Circuit/System Testing

  1. Ignition OFF, disconnect the harness connector at the appropriate actuator.
  2. Ignition OFF, test for less than 10 ohms between the low reference circuit terminal 8 and ground.
  3. If greater than the specified range, test the low reference circuit for an open/high resistance. If the circuit tests normal, replace the HVAC control module.
  4. Ignition ON, test for 4.8-5.2 volts between the 5-volt reference circuit terminal 10 and ground.
  5. If less than the specified range, test the 5-volt reference circuit for a short to ground or an open/high resistance. If the circuit tests normal, replace the HVAC control module.
    If greater than the specified range, test the 5-volt reference circuit for a short to voltage. If the circuit tests normal, replace the HVAC control module.
  6. Verify the scan tool Door Position parameter is greater than 250 counts.
  7. If less than the specified range, test the signal circuit terminal 9 for a short to ground. If the circuit tests normal, replace the HVAC control module.
  8. Install a 3A fused jumper wire between the signal circuit terminal 9 and the low reference circuit terminal 8. Verify the scan tool Door Position parameter is less than 3 counts.
  9. If greater than the specified range, test the signal circuit for a short to voltage or an open/high resistance. If the circuit tests normal, replace the HVAC control module.
  10. Ignition OFF, test for less than 10 ohms between the control circuit terminal 5 and ground.
  11. If greater than the specified range, test the control circuit for a short to voltage or an open/high resistance. If circuit tests normal, replace the HVAC control module.
  12. Ignition OFF, test for less than 10 ohms between the control circuit terminal 6 and ground.
  13. If greater than the specified range, test the control circuit for a short to voltage or an open/high resistance. If circuit tests normal, replace the HVAC control module.
  14. Connect a test lamp between control circuit terminal 5 and control circuit terminal 6.
  15. Ignition ON, command the appropriate actuator door in both directions with a scan tool. The test lamp should turn ON and OFF when commanded in both directions.
  16. If the test lamp remains OFF during either of the commands, test for a short to ground on either control circuit. If the circuits test normal, replace the HVAC control module.
  17. If both circuits test normal, test or replace the actuator.

Repair Instructions

Perform the Diagnostic Repair Verification after completing the diagnostic procedure.

    •  Recirculation Actuator Replacement
    •  Mode Actuator Replacement
    •  Temperature Valve Actuator Replacement - Left Side
    •  Temperature Valve Actuator Replacement - Right Side
    •  Auxiliary Temperature Valve Actuator Replacement
    •  Auxiliary Mode Valve Actuator Replacement
    •  Control Module References for HVAC control module and HVAC Auxiliary control module or rear seat audio (RSA) replacement, setup, and programming